ZEPHAIRE-100-GCONVECTION OVENINSTALLATION - OPERATION - MAINTENANCE(Formerly ZEPHAIRE-240G PLUS)BLODGETT OVEN COMPANYwww.blodgett.com44 Lakeside Aven
8InstallationVentilationDIRECT FLUE ARRANGEMENTWhen the installation of a mechanically driven exhaust hood is impractical the oven may be vented by a
9InstallationUtility Connections - Standards and CodesTHE INSTALLATION INSTRUCTIONS CONTAINED HEREIN ARE FOR THE USE OF QUALIFIED INSTAL-LATION AND SE
10InstallationGas ConnectionGAS PIPINGA properly sized gas supply system is essential for maxi-mum oven performance. Piping should be sized to pro
11InstallationGas ConnectionPRESSURE REGULATION AND TESTINGZephaire-100-G ovens are rated at 50,000 BTU/Hr. (14.6 kW) (53 MJ) per section. Each oven h
12InstallationGas ConnectionGAS HOSE RESTRAINTIf the oven is mounted on casters, a commercial exible connector with a minimum of 3/4” (1.9 cm) inside
13InstallationElectrical ConnectionWiring diagrams are located in the control compartment and on the back of the oven.This oven is supplied for connec
14InstallationInitial StartupThe following is a check-list to be completed by qualied personnel prior to turning on the appliance for the r
15OperationSafety InformationThe information contained in this section is provided for the use of qualied operating personnel. Qualied operat-ing pe
16OperationLIGHT OFF OVEN READYLIGHTSBLOWERHILOWOFFOFFONCOOLDOWNCOOKGAS ONGAS OFFMODE1456327Figure 11 CONTROL DESCRIPTION1. CAVITY LIGHTS ON/OFF - Op
17OperationSSD Solid State Digital ControlLIGHTSBLOWERHILOWOFFOFFONCOOLDOWNCOOKGAS ONGAS OFFMODE1459326781210111314CONTROL DESCRIPTION1. CAVITY LIGHT
Your Service Agency’s Address:ModelSerial numberOven installed byInstallation checked by
18OperationTo set the hold time:1. Press HOLD key (12) to turn hold mode on.NOTE: HOLD light is on.2. Rotate dial (8) to enter the hold temperature
19OperationGeneral Guidelines for Operating PersonnelCOOK TIMES AND TEMPERATURESPreheating the ovenAlways preheat the oven before baking or roasting.
20OperationSuggested Times and TemperaturesPRODUCT TEMPERATURE TIME # SHELVESMeatsHamburger Patties (5 per lb)Steamship Round (80 lb. quartered)Standi
21MaintenanceCleaning and Preventative MaintenanceCLEANING THE OVEN WARNING!!Always clean the unit when it is cold. WARNING!!Be sure to read and follo
22MaintenanceTroubleshooting GuidePOSSIBLE CAUSE(S) SUGGESTED REMEDYSYMPTOM: Oven will not re.• Gas turned off.• Oven not plugged in.• Power switc
TABLE OF CONTENTSINSTALLATIONOven Description and Specications ... 2Delivery and Location ...
2InstallationOven Description and SpecicationsGAS RATINGS - ZEPHAIRE-100-GNatural Gas PropaneUS Units SI Units US Units SI UnitsHeating Value 1000 BT
3InstallationDelivery and LocationDELIVERY AND INSPECTIONAll Blodgett ovens are shipped in containers to prevent damage. Upon delivery of your new ove
4InstallationOven AssemblyNSF BOLTSThese bolts are required by NSF to block any exposed hole on the back of an oven. This includes:• any unit,
5InstallationOven AssemblyLEG ATTACHMENT1. Push the oven onto a lift with the bottom of the oven down.2. Align the threaded stud in each leg with th
6InstallationDOUBLE SECTION ASSEMBLY1. Secure the short legs to the bottom sections as de-scribed.2. Place the upper section in position on top of t
7InstallationVentilationOn gas models the installation of a proper ventilation sys-tem cannot be over emphasized. This system removes unwanted v
Kommentare zu diesen Handbüchern